LO 5-3805-254-12
LUBRICATION ORDER
25 February 1993
(Supersedes LO 5-3805-254-12,
dated 20 January 1988)
TRUCK, DUMP: 20-TON, 6 X 4,
ON-OFF HIGHWAY, 71,000 GVW
(NSN 3805-00-192-7249)
IHC MODEL F-5070 (CCE)
Reference: TM 5-3805-254-10, TM 5-3805-254-20, and C9100-IL.
and gloves, and use only in a well-ventilated
Intervals (on-condition or hard time) and the related
man-hour times are based on normal operation. The
area. Avoid contact with skin, eyes, and
clothes, and DO NOT breathe vapors. DO NOT
man-hour time specified is the time you need to do all
the services prescribed for a particular interval.
use near open flame or excessive heat. The
On-condition (OC) oil sample intervals shall be
solvent's flash point is 100F-138F
applied unless changed by the Army Oil Analysis
(38C-59C). If you become dizzy while using
Program (AOAP) laboratory. Change the hard time
cleaning solvent, immediately get fresh air and
medical help. If solvent contacts eyes,
interval if your lubricants are contaminated or if you
Immediately wash your eyes and get medical
are operating the equipment under adverse
operating conditions, including longer-than-usual
aid.
operating hours. The hard time interval may be
Clean fittings before lubricating. Clean parts with dry
extended during periods of low activity. If extended,
cleaning solvent P-D-880, Type II or equivalent. Dry
adequate preservation precautions must be taken.
before lubricating.
Hard time intervals will be applied in the event AOAP
laboratory support is not available.
Broken arrow shafts (- - -) indicate lubrication
points on both sides of the equipment.
WARNING
The lowest level of maintenance authorized to
lubricate a point is indicated by one of the following:
(C) for Crew/Operator, o r ( 0 ) O r g a n i z a t i o n a l
Dry cleaning solvent, P-D-680, is toxic and
Maintenance.
flammable. Always wear protective goggles
REPORTING ERRORS AND RECOMMENDING IMPROVEMENTS
You can help improve this manual. If you find any mistakes or if you know of a way to improve the
procedures, please let us know. Mail your letter or DA Form 2028 (Recommended Changes to
Publications and Blank forms) direct to: Commander, U.S. Army Tank-Automotive Command, ATTN:
AMSTA-MB, Warren, Ml 48397-5000. A reply will be furnished to you.
Approved for public release; distribution is unlimited.
TA701863
CARD 1 OF 8
LO 5-3805-254-12
