TM-5-3805-254-20-1 Truck Dump 20-Ton 6x4 On-Off Highway 71 000 GVW IHC Model F-5070 (CCE) Manual

CHAPTER 1 INTRODUCTION - TM-5-3805-254-20-1_16
EQUIPMENT IMPROVEMENT REPORT AND MAINTENANCE DIGEST
LOCATION AND DESCRIPTION OF MAJOR COMPONENTS - TM-5-3805-254-20-1_18
ENGINE COMPARTMENT - CONTINUED
LOCATION AND DESCRIPTION OF MAJOR COMPONENTS - CONTINUED - TM-5-3805-254-20-1_20
LOCATION AND DESCRIPTION OF MAJOR COMPONENTS - CONTINUED - TM-5-3805-254-20-1_21
LOCATION AND DESCRIPTION OF MAJOR COMPONENTS - CONTINUED - TM-5-3805-254-20-1_22
EXTERIOR LIGHTS - CONTINUED
LOCATION AND DESCRIPTION OF MAJOR COMPONENTS - CONTINUED - TM-5-3805-254-20-1_24
Operators Seat
LOCATION AND DESCRIPTION OF MAJOR COMPONENTS - CONTINUED - TM-5-3805-254-20-1_26
Exhaust Diverter Valve
Front Hub
Batteries (four)
Air Reservoir Tanks (two)
Main Transmission - TM-5-3805-254-20-1_31
Fenders
EQUIPMENT DATA
EQUIPMENT DATA - CONTINUED
BRAKE SYSTEM - CONTINUED - TM-5-3805-254-20-1_35
BRAKE SYSTEM - CONTINUED - TM-5-3805-254-20-1_36
Section III. PRINCIPLES OF OPERATION
POWER TRAIN - CONTINUED
AUXILIARY TRANSMISSION - TM-5-3805-254-20-1_39
MAIN TRANSMISSION - TM-5-3805-254-20-1_40
ENGINE OIL FILTER
EXHAUST SYSTEM
ANEROID CONTROL VALVE
ACCELERATOR CONTROL
THERMOSTAT - TM-5-3805-254-20-1_45
HEADLIGHTS (Two)
TURN SIGNAL SWITCH - TM-5-3805-254-20-1_47
GENERATOR WITH INTEGRAL VOLTAGE REGULATOR
STARTER SOLENOID
ENGINE START BUTTON - TM-5-3805-254-20-1_50
GLOW PLUG ON/OFF SWITCH
HEADLIGHT BEAM DIMMER SWITCH
OIL PRESSURE/WATER TEMPERATURE INDICATOR LAMP
BATTERY CHARGE VOLTS GAGE
TRANSMISSION TEMP INDICATOR LAMP SWITCH
COMPRESSION BRAKE PRESSURE SWITCH
BACKUP LIGHT SWITCH - TM-5-3805-254-20-1_57
COMPRESSION BRAKE THROTTLE SWITCH
ENGINE WATER TEMPERATURE SAFETY SWITCH
AIR PRESSURE GAGE - TM-5-3805-254-20-1_60
SPEEDOMETER - ODOMETER
ENGINE WATER TEMP GAGE
WIPER MOTOR (Two)
TAILGATE RELEASE LEVER
TREADLE VALVE
RELAY VALVES (Two)
REAR BRAKE ASSEMBLIES (Four)
PARKING BRAKE CONTROL VALVE - TM-5-3805-254-20-1_68
HYDRAULIC OIL RESERVOIR - TM-5-3805-254-20-1_69
CHAPTER 2 MAINTENANCE INSTRUCTIONS
Section II. SERVICE UPON RECEIPT
Section III. LUBRICATION INSTRUCTIONS
ENGINE OIL
FILLING - TM-5-3805-254-20-1_74
ENGINE FULL-FLOW OIL FILTER
ENGINE FULL-FLOW OIL FILTER - CONTINUED - TM-5-3805-254-20-1_76
CLEANING - TM-5-3805-254-20-1_77
ENGINE FULL-FLOW OIL FILTER - CONTINUED - TM-5-3805-254-20-1_78
ENGINE AUXILIARY OIL FILTER
ENGINE AUXILIARY OIL FILTER - CONTINUED - TM-5-3805-254-20-1_80
CLEANING - TM-5-3805-254-20-1_81
ENGINE AUXILIARY OIL FILTER - CONTINUED - TM-5-3805-254-20-1_82
REMOVAL - TM-5-3805-254-20-1_83
INSPECTION/REPLACEMENT - TM-5-3805-254-20-1_84
INSTALLATION - TM-5-3805-254-20-1_85
FAN HUB
LUBRICATION - CONTINUED
WATER PUMP
WATER PUMP - CONTINUED
Section IV. ORGANIZATIONAL PREVENTIVE MAINTENANCE CHECKS AND SERVICES (PMCS)
ORGANIZATIONAL PREVENTIVE MAINTENANCE CHECKS AND SERVICES (PMCS) - CONTINUED - TM-5-3805-254-20-1_91
ORGANIZATIONAL PREVENTIVE MAINTENANCE CHECKS AND SERVICES (PMCS) - CONTINUED - TM-5-3805-254-20-1_92
ORGANIZATIONAL PREVENTIVE MAINTENANCE CHECKS AND SERVICES (PMCS) - CONTINUED - TM-5-3805-254-20-1_93
ORGANIZATIONAL PREVENTIVE MAINTENANCE CHECKS AND SERVICES (PMCS) - CONTINUED - TM-5-3805-254-20-1_94
ORGANIZATIONAL PREVENTIVE MAINTENANCE CHECKS AND SERVICES (PMCS) - CONTINUED - TM-5-3805-254-20-1_95
ORGANIZATIONAL PREVENTIVE MAINTENANCE CHECKS AND SERVICES (PMCS) - CONTINUED - TM-5-3805-254-20-1_96
ORGANIZATIONAL PREVENTIVE MAINTENANCE CHECKS AND SERVICES (PMCS) - CONTINUED - TM-5-3805-254-20-1_97
ORGANIZATIONAL PREVENTIVE MAINTENANCE CHECKS AND SERVICES (PMCS) - CONTINUED - TM-5-3805-254-20-1_98
ORGANIZATIONAL PREVENTIVE MAINTENANCE CHECKS AND SERVICES (PMCS) - CONTINUED - TM-5-3805-254-20-1_99
ORGANIZATIONAL PREVENTIVE MAINTENANCE CHECKS AND SERVICES (PMCS) - CONTINUED - TM-5-3805-254-20-1_100
ORGANIZATIONAL PREVENTIVE MAINTENANCE CHECKS AND SERVICES (PMCS) - CONTINUED - TM-5-3805-254-20-1_101
ORGANIZATIONAL PREVENTIVE MAINTENANCE CHECKS AND SERVICES (PMCS) - CONTINUED - TM-5-3805-254-20-1_102
ORGANIZATIONAL PREVENTIVE MAINTENANCE CHECKS AND SERVICES (PMCS) - CONTINUED - TM-5-3805-254-20-1_103
ORGANIZATIONAL PREVENTIVE MAINTENANCE CHECKS AND SERVICES (PMCS) - CONTINUED - TM-5-3805-254-20-1_104
ORGANIZATIONAL PREVENTIVE MAINTENANCE CHECKS AND SERVICES (PMCS) - CONTINUED - TM-5-3805-254-20-1_105
ORGANIZATIONAL PREVENTIVE MAINTENANCE CHECKS AND SERVICES (PMCS) - CONTINUED - TM-5-3805-254-20-1_106
WET AIR RESERVOIR - TM-5-3805-254-20-1_107
ORGANIZATIONAL PREVENTIVE MAINTENANCE CHECKS AND SERVICES (PMCS) - CONTINUED - TM-5-3805-254-20-1_108
DUMP BODY
DUMP BODY HYDRAULICS
DUMP BODY HYDRAULICS - CONTINUED
Section V. ORGANIZATIONAL TROUBLESHOOTING
SYMPTOM INDEX - CONTINUED - TM-5-3805-254-20-1_113
SYMPTOM INDEX - CONTINUED - TM-5-3805-254-20-1_114
ORGANIZATIONAL TROUBLESHOOTING
MALFUNCTION TEST OR INSPECTION CORRECTIVE ACTION
ENGINE CRANKS BUT FAILS TO START BELOW 50F (18C) - CONTINUED - TM-5-3805-254-20-1_117
ENGINE CRANKS BUT FAILS TO START BELOW 50F (18C) - CONTINUED - TM-5-3805-254-20-1_118
ENGINE CRANKS BUT FAILS TO START BELOW 50F (18C) - CONTINUED - TM-5-3805-254-20-1_119
ENGINE CRANKS BUT FAILS TO START BELOW 50F (18C) - CONTINUED - TM-5-3805-254-20-1_120
ENGINE CRANKS BUT FAILS TO START BELOW 50F (18C) - CONTINUED - TM-5-3805-254-20-1_121
ENGINE CRANKS BUT FAILS TO START BELOW 50F (18C) - CONTINUED - TM-5-3805-254-20-1_122
ENGINE CRANKS BUT FAILS TO START BELOW 50F (18C) - CONTINUED - TM-5-3805-254-20-1_123
ENGINE CRANKS BUT FAILS TO START BELOW 50F (18C) - CONTINUED - TM-5-3805-254-20-1_124
ENGINE CRANKS BUT FAILS TO START BELOW 50F (18C) - CONTINUED - TM-5-3805-254-20-1_125
ENGINE CRANKS BUT FAILS TO START BELOW 50F (18C) - CONTINUED - TM-5-3805-254-20-1_126
ENGINE CRANKS BUT FAILS TO START BELOW 50F (18C) - CONTINUED - TM-5-3805-254-20-1_127
ENGINE CRANKS BUT FAILS TO START BELOW 50F (18C) - CONTINUED - TM-5-3805-254-20-1_128
ENGINE CRANKS BUT FAILS TO START BELOW 50F (18C) - CONTINUED - TM-5-3805-254-20-1_129
ENGINE CRANKS BUT FAILS TO START BELOW 50F (18C) - CONTINUED - TM-5-3805-254-20-1_130
ENGINE CRANKS BUT FAILS TO START BELOW 50F (18C) - CONTINUED - TM-5-3805-254-20-1_131
ENGINE CRANKS BUT FAILS TO START BELOW 50F (18C) - CONTINUED - TM-5-3805-254-20-1_132
ENGINE CRANKS BUT FAILS TO START BELOW 50F (18C) - CONTINUED - TM-5-3805-254-20-1_133
ENGINE CRANKS BUT FAILS TO START BELOW 50F (18C) - CONTINUED - TM-5-3805-254-20-1_134
ENGINE CRANKS BUT FAILS TO START BELOW 50F (18C) - CONTINUED - TM-5-3805-254-20-1_135
ENGINE CRANKS BUT FAILS TO START BELOW 50F (18C) - CONTINUED - TM-5-3805-254-20-1_136
ENGINE CRANKS BUT FAILS TO START ABOVE 50F (18C)
ENGINE CRANKS BUT FAILS TO START ABOVE 50F (18C)-cont.
ENGINE CRANKS BUT FAILS TO START ABOVE 50F (18C) CONTINUED - TM-5-3805-254-20-1_139
ENGINE CRANKS BUT FAILS TO START ABOVE 50F (18C) CONTINUED - TM-5-3805-254-20-1_140
ENGINE CRANKS BUT FAILS TO START ABOVE 50F (18C) CONTINUED - TM-5-3805-254-20-1_141
Step 9 Check engine OIL PRESSURE gage
Step 10. Check engine oil pressure switch
Step 12
Step 14 Check for 11 to 13 vdc to fuse panel
ENGINE CRANKS BUT FAILS TO START ABOVE 50F (18C) - CONTINUED - TM-5-3805-254-20-1_146
ENGINE CRANKS BUT FAILS TO START ABOVE 50F (18C) - CONTINUED - TM-5-3805-254-20-1_147
ENGINE CRANKS BUT FAILS TO START ABOVE 50F (18C) - CONTINUED - TM-5-3805-254-20-1_148
ENGINE CRANKS BUT FAILS TO START ABOVE 50F (18C) - CONTINUED - TM-5-3805-254-20-1_149
ENGINE CRANKS BUT FAILS TO START ABOVE 50F (18C) - CONTINUED - TM-5-3805-254-20-1_150
ENGINE CRANKS BUT FAILS TO START ABOVE 50F (18C) - CONTINUED - TM-5-3805-254-20-1_151
ENGINE CRANKS BUT FAILS TO START ABOVE 50F (18C) - CONTINUED - TM-5-3805-254-20-1_152
ENGINE CRANKS BUT FAILS TO START ABOVE 50F (18C) - CONTINUED - TM-5-3805-254-20-1_153
ENGINE CRANKS BUT FAILS TO START ABOVE 50F (18C) - CONTINUED - TM-5-3805-254-20-1_154
ENGINE FAILS TO CRANK - TM-5-3805-254-20-1_155
ENGINE FAILS TO CRANK - TM-5-3805-254-20-1_156
ENGINE FAILS TO CRANK - CONTINUED - TM-5-3805-254-20-1_157
ENGINE FAILS TO CRANK - CONTINUED - TM-5-3805-254-20-1_158
ENGINE FAILS TO CRANK - CONTINUED - TM-5-3805-254-20-1_159
ENGINE FAILS TO CRANK - CONTINUED - TM-5-3805-254-20-1_160
ENGINE FAILS TO CRANK - CONTINUED - TM-5-3805-254-20-1_161
ENGINE FAILS TO CRANK - CONTINUED - TM-5-3805-254-20-1_162
ENGINE FAILS TO CRANK - CONTINUED - TM-5-3805-254-20-1_163
ENGINE FAILS TO CRANK - CONTINUED - TM-5-3805-254-20-1_164
ENGINE FAILS TO CRANK - CONTINUED - TM-5-3805-254-20-1_165
ENGINE FAILS TO CRANK - CONTINUED - TM-5-3805-254-20-1_166
ENGINE FAILS TO CRANK - CONTINUED - TM-5-3805-254-20-1_167
ENGINE FAILS TO CRANK - CONTINUED - TM-5-3805-254-20-1_168
ENGINE FAILS TO CRANK - CONTINUED - TM-5-3805-254-20-1_169
ENGINE FAILS TO CRANK - CONTINUED - TM-5-3805-254-20-1_170
ENGINE FAILS TO CRANK - CONTINUED - TM-5-3805-254-20-1_171
ENGINE FAILS TO CRANK - CONTINUED - TM-5-3805-254-20-1_172
ENGINE COOLANT TEMPERATURE EXCEEDS 2250F (1070C) - TM-5-3805-254-20-1_173
ENGINE COOLANT TEMPERATURE EXCEEDS 2250F (1070C) - TM-5-3805-254-20-1_174
ENGINE COOLANT TEMPERATURE EXCEEDS 2250F (1070C) - CONTINUED - TM-5-3805-254-20-1_175
ENGINE COOLANT TEMPERATURE EXCEEDS 2250F (1070C) - CONTINUED - TM-5-3805-254-20-1_176
ENGINE DOES NOT REACH OPERATING TEMPERATURE, 165F (740C)
ENGINE TACHOMETER DOES NOT WORK
ENGINE WILL NOT SHUT DOWN
ENGINE OIL PRESSURE INDICATION BELOW 15 PSI AT IDLE
For normal operating engine oil pressure refer to TM 5-3805-254-10
ENGINE USES TOO MUCH FUEL
ENGINE KNOCKS
ENGINE USES TOO MUCH OIL-cont.
ENGINE BLOWS BLACK OR GREY SMOKE - TM-5-3805-254-20-1_185
ENGINE BLOWS BLACK OR GREY SMOKE - TM-5-3805-254-20-1_186
ENGINE LACKS POWER - TM-5-3805-254-20-1_187
ENGINE LACKS POWER - TM-5-3805-254-20-1_188
ENGINE LACKS POWER - CONTINUED
ENGINE COMPRESSION BRAKE DOES NOT WORK.
ENGINE COMPRESSION BRAKE DOES NOT WORK - CONTINUED - TM-5-3805-254-20-1_191
ENGINE COMPRESSION BRAKE DOES NOT WORK - CONTINUED - TM-5-3805-254-20-1_192
ENGINE COMPRESSION BRAKE DOES NOT WORK - CONTINUED - TM-5-3805-254-20-1_193
ENGINE COMPRESSION BRAKE DOES NOT WORK - CONTINUED - TM-5-3805-254-20-1_194
ENGINE COMPRESSION BRAKE DOES NOT WORK -CONTINUED
ENGINE STARTS BUT DOES NOT STAY RUNNING
ENGINE STARTS BUT DOES NOT STAY RUNNING - CONTINUED - TM-5-3805-254-20-1_197
ENGINE STARTS BUT DOES NOT STAY RUNNING - CONTINUED - TM-5-3805-254-20-1_198
ENGINE STARTS BUT DOES NOT STAY RUNNING - CONTINUED - TM-5-3805-254-20-1_199
ENGINE STARTS BUT DOES NOT STAY RUNNING - CONTINUED - TM-5-3805-254-20-1_200
ELECTRICAL SYSTEM
ALL LIGHTS DO NOT WORK-cont.
ALL LIGHTS DO NOT WORK - CONTINUED - TM-5-3805-254-20-1_203
ALL LIGHTS DO NOT WORK - CONTINUED - TM-5-3805-254-20-1_204
ALL LIGHTS DO NOT WORK - CONTINUED - TM-5-3805-254-20-1_205
ALL LIGHTS DO NOT WORK - CONTINUED - TM-5-3805-254-20-1_206
ALL LIGHTS DO NOT WORK - CONTINUED - TM-5-3805-254-20-1_207
ALL LIGHTS DO NOT WORK - CONTINUED - TM-5-3805-254-20-1_208
ALL LIGHTS DO NOT WORK - CONTINUED - TM-5-3805-254-20-1_209
BOTH BACKUP LIGHTS DO NOT WORK
BOTH BACKUP LIGHTS DO NOT WORK - CONTINUED - TM-5-3805-254-20-1_211
BOTH BACKUP LIGHTS DO NOT WORK - CONTINUED - TM-5-3805-254-20-1_212
BOTH BACKUP LIGHTS DO NOT WORK - CONTINUED - TM-5-3805-254-20-1_213
BOTH BACKUP LIGHTS DO NOT WORK - CONTINUED - TM-5-3805-254-20-1_214
BOTH BACKUP LIGHTS DO NOT WORK - CONTINUED. - TM-5-3805-254-20-1_215
ORGANIZATIONAL TROUBLESHOOTING - CONTINUED - TM-5-3805-254-20-1_216
BOTH BACKUP LIGHTS DO NOT WORK - CONTINUED. - TM-5-3805-254-20-1_217
ORGANIZATIONAL TROUBLESHOOTING - CONTINUED - TM-5-3805-254-20-1_218
BOTH BACKUP LIGHTS DO NOT WORK - CONTINUED - TM-5-3805-254-20-1_219
BOTH BACKUP LIGHTS DO NOT WORK - CONTINUED - TM-5-3805-254-20-1_220
BOTH BACKUP LIGHTS DO NOT WORK - CONTINUED - TM-5-3805-254-20-1_221
ORGANIZATIONAL TROUBLESHOOTING - CONTINUED - TM-5-3805-254-20-1_222
BOTH BACKUP LIGHTS DO NOT WORK - CONTINUED - TM-5-3805-254-20-1_223
ORGANIZATIONAL TROUBLESHOOTING - CONTINUED - TM-5-3805-254-20-1_224
BOTH BACKUP LIGHTS DO NOT WORK - CONTINUED - TM-5-3805-254-20-1_225
ORGANIZATIONAL TROUBLESHOOTING - CONTINUED - TM-5-3805-254-20-1_226
ONE BACKUP LIGHT DOES NOTWORK
ONE BACKUP LIGHT DOES NOTWORK-cont.
ONE BACKUP LIGHT DOES NOT WORK - CONTINUED - TM-5-3805-254-20-1_229
ONE BACKUP LIGHT DOES NOT WORK - CONTINUED - TM-5-3805-254-20-1_230
ONE BACKUP LIGHT DOES NOT WORK - CONTINUED - TM-5-3805-254-20-1_231
ONE BACKUP LIGHT DOES NOT WORK - CONTINUED - TM-5-3805-254-20-1_232
ONE BACKUP LIGHT DOES NOT WORK - CONTINUED - TM-5-3805-254-20-1_233
ONE BACKUP LIGHT DOES NOT WORK - CONTINUED - TM-5-3805-254-20-1_234
ONE BACKUP LIGHT DOES NOT WORK - CONTINUED - TM-5-3805-254-20-1_235
ONE BACKUP LIGHT DOES NOT WORK - CONTINUED - TM-5-3805-254-20-1_236
BOTH HEADLIGHTS DO NOT WORK
BOTH HEADLIGHTS DO NOT WORK-cont.
BOTH HEADLIGHTS DO NOT WORK - CONTINUED - TM-5-3805-254-20-1_239
BOTH HEADLIGHTS DO NOT WORK - CONTINUED - TM-5-3805-254-20-1_240
BOTH HEADLIGHTS DO NOT WORK - CONTINUED - TM-5-3805-254-20-1_241
BOTH HEADLIGHTS DO NOT WORK - CONTINUED - TM-5-3805-254-20-1_242
BOTH HEADLIGHTS DO NOT WORK - CONTINUED - TM-5-3805-254-20-1_243
BOTH HEADLIGHTS DO NOT WORK - CONTINUED - TM-5-3805-254-20-1_244
BOTH HEADLIGHTS DO NOT WORK - CONTINUED - TM-5-3805-254-20-1_245
ORGANIZATIONAL TROUBLESHOOTING - CONTINUED - TM-5-3805-254-20-1_246
BOTH HEADLIGHTS DO NOT WORK - CONTINUED - TM-5-3805-254-20-1_247
BOTH HEADLIGHTS DO NOT WORK - CONTINUED - TM-5-3805-254-20-1_248
BOTH HEADLIGHTS DO NOT WORK - CONTINUED - TM-5-3805-254-20-1_249
BOTH HEADLIGHTS DO NOT WORK - CONTINUED - TM-5-3805-254-20-1_250
BOTH HEADLIGHTS DO NOT WORK - CONTINUED - TM-5-3805-254-20-1_251
BOTH HEADLIGHTS DO NOT WORK - CONTINUED - TM-5-3805-254-20-1_252
BOTH HEADLIGHTS DO NOT WORK - CONTINUED - TM-5-3805-254-20-1_253
BOTH HEADLIGHTS DO NOT WORK - CONTINUED - TM-5-3805-254-20-1_254
BOTH HEADLIGHTS DO NOT WORK - CONTINUED - TM-5-3805-254-20-1_255
BOTH HEADLIGHTS DO NOT WORK - CONTINUED - TM-5-3805-254-20-1_256
BOTH HEADLIGHTS DO NOT WORK - CONTINUED - TM-5-3805-254-20-1_257
BOTH HEADLIGHTS DO NOT WORK - CONTINUED - TM-5-3805-254-20-1_258
BOTH HEADLIGHTS DO NOT WORK - CONTINUED - TM-5-3805-254-20-1_259
BOTH HEADLIGHTS DO NOT WORK - CONTINUED - TM-5-3805-254-20-1_260
BOTH HEADLIGHTS DO NOT WORK - CONTINUED - TM-5-3805-254-20-1_261
BOTH HEADLIGHTS DO NOT WORK - CONTINUED - TM-5-3805-254-20-1_262
ONE HEADLIGHT DOES NOT WORK - TM-5-3805-254-20-1_263
ONE HEADLIGHT DOES NOT WORK - TM-5-3805-254-20-1_264
ONE HEADLIGHT DOES NOTWORK - CONTINUED - TM-5-3805-254-20-1_265
ONE HEADLIGHT DOES NOTWORK - CONTINUED - TM-5-3805-254-20-1_266
ONE HEADLIGHT DOES NOTWORK - CONTINUED - TM-5-3805-254-20-1_267
ONE HEADLIGHT DOES NOTWORK - CONTINUED - TM-5-3805-254-20-1_268
ONE HEADLIGHT DOES NOT WORK - CONTINUED - TM-5-3805-254-20-1_269
ONE HEADLIGHT DOES NOT WORK - CONTINUED - TM-5-3805-254-20-1_270
ONE HEADLIGHT DOES NOTWORK - CONTINUED - TM-5-3805-254-20-1_271
ONE HEADLIGHT DOES NOTWORK - CONTINUED - TM-5-3805-254-20-1_272
ONE HEADLIGHT DOES NOTWORK - CONTINUED - TM-5-3805-254-20-1_273
ONE HEADLIGHT DOES NOTWORK - CONTINUED - TM-5-3805-254-20-1_274
ALL TURN SIGNALS DO NOT WORK
ALL TURN SIGNALS DO NOT WORK-cont.
ALL TURN SIGNALS DO NOT WORK - CONTINUED - TM-5-3805-254-20-1_277
ALL TURN SIGNALS DO NOT WORK - CONTINUED - TM-5-3805-254-20-1_278
ALL TURN SIGNALS DO NOT WORK - CONTINUED - TM-5-3805-254-20-1_279
ALL TURN SIGNALS DO NOT WORK - CONTINUED - TM-5-3805-254-20-1_280
BATTERIES DO NOT HOLD A CHARGE
GENERATOR DOES NOT CHARGE
GENERATOR DOES NOT CHARGE - CONTINUED
GENERATOR OVERCHARGES
ALL CAB MOUNTED MARKER LIGHTS DO NOT WORK - TM-5-3805-254-20-1_285
ALL CAB MOUNTED MARKER LIGHTS DO NOT WORK - TM-5-3805-254-20-1_286
ALL DUMP BODY MARKER LIGHTS DO NOT WORK
ONE CAB MOUNTED MARKER LIGHT DOES NOT WORK
ONE CAB MOUNTED MARKER LIGHT DOES NOT WORK - CONTINUED.
Step 3. Check marker lamp socket (4) for corroded or rusted condition.
ONE DUMP BODY MARKER LIGHT DOES NOT WORK - TM-5-3805-254-20-1_291
ONE DUMP BODY MARKER LIGHT DOES NOT WORK - TM-5-3805-254-20-1_292
BOTH FRONT TURN SIGNALS DO NOT WORK
BOTH FRONT TURN SIGNALS DO NOT WORK-cont.
ONE FRONT TURN SIGNAL DOES NOT WORK.
ONE FRONT TURN SIGNAL DOES NOT WORK.-cont.
ONE FRONT TURN SIGNAL DOES NOT WORK - CONTINUED - TM-5-3805-254-20-1_297
ONE FRONT TURN SIGNAL DOES NOT WORK - CONTINUED - TM-5-3805-254-20-1_298
ONE FRONT TURN SIGNAL LIGHT DOES NOT WORK - CONTINUED - TM-5-3805-254-20-1_299
ONE FRONT TURN SIGNAL LIGHT DOES NOT WORK - CONTINUED - TM-5-3805-254-20-1_300
ONE FRONT TURN SIGNAL DOES NOT WORK - CONTINUED - TM-5-3805-254-20-1_301
ONE FRONT TURN SIGNAL DOES NOT WORK - CONTINUED - TM-5-3805-254-20-1_302
ONE FRONT TURN SIGNAL DOES NOT WORK - CONTINUED - TM-5-3805-254-20-1_303
ONE FRONT TURN SIGNAL DOES NOT WORK - CONTINUED - TM-5-3805-254-20-1_304
ONE FRONT TURN SIGNAL DOES NOT WORK - CONTINUED - TM-5-3805-254-20-1_305
ONE FRONT TURN SIGNAL DOES NOT WORK - CONTINUED - TM-5-3805-254-20-1_306
ONE FRONT TURN SIGNAL DOES NOT WORK - CONTINUED - TM-5-3805-254-20-1_307
ONE FRONT TURN SIGNAL DOES NOT WORK - CONTINUED - TM-5-3805-254-20-1_308
ONE FRONT TURN SIGNAL DOES NOT WORK - CONTINUED - TM-5-3805-254-20-1_309
ONE FRONT TURN SIGNAL DOES NOT WORK - CONTINUED - TM-5-3805-254-20-1_310
ONE FRONTTURN SIGNAL DOES NOT WORK - CONTINUED - TM-5-3805-254-20-1_311
ONE FRONTTURN SIGNAL DOES NOT WORK - CONTINUED - TM-5-3805-254-20-1_312
ONE REAR TURN SIGNAL DOES NOT WORK. - TM-5-3805-254-20-1_313
ONE REAR TURN SIGNAL DOES NOT WORK. - TM-5-3805-254-20-1_314
ALL EMERGENCY FLASHERS DO NOT WORK - TM-5-3805-254-20-1_315
ALL EMERGENCY FLASHERS DO NOT WORK - TM-5-3805-254-20-1_316
ALL EMERGENCY FLASHERS DO NOT WORK - CONTINUED - TM-5-3805-254-20-1_317
ALL EMERGENCY FLASHERS DO NOT WORK - CONTINUED - TM-5-3805-254-20-1_318
ALL EMERGENCY FLASHERS DO NOT WORK - CONTINUED - TM-5-3805-254-20-1_319
ALL EMERGENCY FLASHERS DO NOT WORK - CONTINUED - TM-5-3805-254-20-1_320
BOTH FRONT EMERGENCY FLASHERS DO NOT WORK - TM-5-3805-254-20-1_321
BOTH FRONT EMERGENCY FLASHERS DO NOT WORK - TM-5-3805-254-20-1_322
ONE FRONT EMERGENCY FLASHER DOES NOT WORK - TM-5-3805-254-20-1_323
ONE FRONT EMERGENCY FLASHER DOES NOT WORK - TM-5-3805-254-20-1_324
ONE FRONT EMERGENCY FLASHER DOES NOT WORK - CONTINUED - TM-5-3805-254-20-1_325
ONE FRONT EMERGENCY FLASHER DOES NOT WORK - CONTINUED - TM-5-3805-254-20-1_326
ONE FRONT EMERGENCY FLASHER DOES NOT WORK - CONTINUED - TM-5-3805-254-20-1_327
ONE FRONT EMERGENCY FLASHER DOES NOT WORK - CONTINUED - TM-5-3805-254-20-1_328
ONE FRONT EMERGENCY FLASHER DOES NOT WORK - CONTINUED - TM-5-3805-254-20-1_329
ONE FRONT EMERGENCY FLASHER DOES NOT WORK - CONTINUED - TM-5-3805-254-20-1_330
ONE FRONT EMERGENCY FLASHER DOES NOT WORK - CONTINUED - TM-5-3805-254-20-1_331
ONE FRONT EMERGENCY FLASHER DOES NOT WORK - CONTINUED - TM-5-3805-254-20-1_332
ONE FRONT EMERGENCY FLASHER DOES NOT WORK - CONTINUED - TM-5-3805-254-20-1_333
ONE FRONT EMERGENCY FLASHER DOES NOT WORK - CONTINUED - TM-5-3805-254-20-1_334
ONE FRONT EMERGENCY FLASHER DOES NOT WORK - CONTINUED - TM-5-3805-254-20-1_335
ONE FRONT EMERGENCY FLASHER DOES NOT WORK - CONTINUED - TM-5-3805-254-20-1_336
ONE FRONT EMERGENCY FLASHER DOES NOT WORK - CONTINUED - TM-5-3805-254-20-1_337
ONE FRONT EMERGENCY FLASHER DOES NOT WORK - CONTINUED - TM-5-3805-254-20-1_338
ONE FRONT EMERGENCY FLASHER DOES NOT WORK - CONTINUED - TM-5-3805-254-20-1_339
ONE FRONT EMERGENCY FLASHER DOES NOT WORK - CONTINUED - TM-5-3805-254-20-1_340
ONE FRONT EMERGENCY FLASHER DOES NOT WORK - CONTINUED - TM-5-3805-254-20-1_341
ONE REAR EMERGENCY FLASHER DOES NOT WORK - TM-5-3805-254-20-1_342
ONE REAR EMERGENCY FLASHER DOES NOT WORK - TM-5-3805-254-20-1_343
BOTH STOP LIGHTS DO NOT WORK
BOTH STOP LIGHTS DO NOT WORK-cont.
BOTH STOP LIGHTS DO NOT WORK - CONTINUED - TM-5-3805-254-20-1_346
BOTH STOP LIGHTS DO NOT WORK - CONTINUED - TM-5-3805-254-20-1_347
BOTH STOP LIGHTS DO NOT WORK - CONTINUED - TM-5-3805-254-20-1_348
BOTH STOP LIGHTS DO NOT WORK - CONTINUED - TM-5-3805-254-20-1_349
ONE STOPLIGHT DOES NOT WORK
ONE STOPLIGHT DOES NOT WORK-cont.
BOTH TAILLIGHTS DO NOT WORK - TM-5-3805-254-20-1_352
BOTH TAILLIGHTS DO NOT WORK - TM-5-3805-254-20-1_353
ONE TAILLIGHT DOES NOT WORK - TM-5-3805-254-20-1_354
ONE TAILLIGHT DOES NOT WORK - TM-5-3805-254-20-1_355
ONETAILIGHT DOES NOT WORK - CONTINUED - TM-5-3805-254-20-1_356
ONETAILIGHT DOES NOT WORK - CONTINUED - TM-5-3805-254-20-1_357
ONETAILIGHT DOES NOT WORK - CONTINUED - TM-5-3805-254-20-1_358
ONETAILIGHT DOES NOT WORK - CONTINUED - TM-5-3805-254-20-1_359
DOME LIGHT DOES NOT WORK - TM-5-3805-254-20-1_360
DOME LIGHT DOES NOT WORK - TM-5-3805-254-20-1_361
DOME LIGHT DOES NOT WORK - CONTINUED - TM-5-3805-254-20-1_362
DOME LIGHT DOES NOT WORK - CONTINUED - TM-5-3805-254-20-1_363
ENGINE WARNING BELL DOES NOT WORK - TM-5-3805-254-20-1_364
ENGINE WARNING BELL DOES NOT WORK - TM-5-3805-254-20-1_365
OIL PRESSURE/WATER TEMPERATURE INDICATOR LAMP DOES NOT WORK - TM-5-3805-254-20-1_366
OIL PRESSURE/WATER TEMPERATURE INDICATOR LAMP DOES NOT WORK - TM-5-3805-254-20-1_367
GLOW PLUG INDICATOR LAMP DOES NOT WORK. - TM-5-3805-254-20-1_368
GLOW PLUG INDICATOR LAMP DOES NOT WORK. - TM-5-3805-254-20-1_369
INSTRUMENT PANEL LAMPS DO NOT WORK - TM-5-3805-254-20-1_370
INSTRUMENT PANEL LAMPS DO NOT WORK - TM-5-3805-254-20-1_371
LEFT TURN SIGNAL INDICATOR LAMP DOES NOT WORK - TM-5-3805-254-20-1_372
LEFT TURN SIGNAL INDICATOR LAMP DOES NOT WORK - TM-5-3805-254-20-1_373
LOW AIR-PRESSURE BUZZER DOES NOT WORK - TM-5-3805-254-20-1_374
LOW AIR-PRESSURE BUZZER DOES NOT WORK - TM-5-3805-254-20-1_375
POWER TAKE OFF INDICATOR LAMP DOES NOT WORK - TM-5-3805-254-20-1_376
POWER TAKE OFF INDICATOR LAMP DOES NOT WORK - TM-5-3805-254-20-1_377
POWER TAKE OFF INDICATOR LAMP DOES NOT WORK - CONTINUED. - TM-5-3805-254-20-1_378
POWER TAKE OFF INDICATOR LAMP DOES NOT WORK - CONTINUED. - TM-5-3805-254-20-1_379
RIGHT TURN SIGNAL INDICATOR LAMP DOES NOT WORK - TM-5-3805-254-20-1_380
RIGHT TURN SIGNAL INDICATOR LAMP DOES NOT WORK - TM-5-3805-254-20-1_381
TRANSMISSION POSITION INDICATOR LAMP DOES NOT WORK. - TM-5-3805-254-20-1_382
TRANSMISSION POSITION INDICATOR LAMP DOES NOT WORK. - TM-5-3805-254-20-1_383
MAIN TRANSMISSION - TM-5-3805-254-20-1_384
TRANSMISSION DOES NOT OPERATE IN ANY GEAR
TRANSMISSION DOES NOT OPERATE IN ANY GEAR - CONTINUED
TRANSMISSION DOES NOT SHIFT PROPERLY
TRANSMISSION DOES NOT SHIFT PROPERLY - CONTINUED - TM-5-3805-254-20-1_388
TRANSMISSION DOES NOT SHIFT PROPERLY - CONTINUED - TM-5-3805-254-20-1_389
TRANSMISSION DOES NOT SHIFT PROPERLY CONTINUED
TRANSMISSION OIL TEMPERATURE EXCEEDS 300F (149C).
TRANSMISSION OIL TEMPERATURE EXCEEDS 3000F (1490C)CONTINUED
TRANSMISSION SLIPS.
TRANSMISSION SLIPS CONTINUED - TM-5-3805-254-20-1_394
TRANSMISSION SLIPS CONTINUED - TM-5-3805-254-20-1_395
AIR SYSTEM AND BRAKES
AIR SYSTEM AND BRAKES-cont.
AIR HORN DOES NOT WORK CONTINUED - TM-5-3805-254-20-1_398
AIR HORN DOES NOT WORK CONTINUED - TM-5-3805-254-20-1_399
ALL BRAKES DO NOT OPERATE
ALL BRAKES DO NOT OPERATE-cont.
FRONT BRAKES DO NOT RELEASE
FRONT BRAKES DO NOT RELEASE-cont.
FRONT BRAKES DO NOT RELEASE - CONTINUED
REAR BRAKES DO NOT RELEASE
REAR BRAKES DO NOT RELEASE - CONTINUED - TM-5-3805-254-20-1_406
REAR BRAKES DO NOT RELEASE - CONTINUED - TM-5-3805-254-20-1_407
REAR BRAKES DO NOT RELEASE - CONTINUED - TM-5-3805-254-20-1_408
AIR PRESSURE DOES NOT EXCEED 90 PSI
AIR PRESSURE DOES NOT EXCEED 90 PSI - CONTINUED - TM-5-3805-254-20-1_410
AIR PRESSURE DOES NOT EXCEED 90 PSI - CONTINUED - TM-5-3805-254-20-1_411
AIR PRESSURE DOES NOT EXCEED 90 PSI - CONTINUED. - TM-5-3805-254-20-1_412
AIR PRESSURE DOES NOT EXCEED 90 PSI - CONTINUED. - TM-5-3805-254-20-1_413
AIR PRESSURE EXCEEDS 130 PSI - TM-5-3805-254-20-1_414
AIR PRESSURE EXCEEDS 130 PSI - TM-5-3805-254-20-1_415
AIR BRAKES DO NOT RELEASE
AIR BRAKES DO NOT RELEASE-cont.
AIR BRAKES DO NOT RELEASE - CONTINUED - TM-5-3805-254-20-1_418
AIR BRAKES DO NOT RELEASE - CONTINUED - TM-5-3805-254-20-1_419
FRONT BRAKES DO NOT WORK
FRONT BRAKES DO NOT WORK-cont.
FRONT BRAKES DO NOT WORK - CONTINUED - TM-5-3805-254-20-1_422
FRONT BRAKES DO NOT WORK - CONTINUED - TM-5-3805-254-20-1_423
FRONT BRAKES DO NOT WORK - CONTINUED - TM-5-3805-254-20-1_424
FRONT BRAKES DO NOT WORK - CONTINUED - TM-5-3805-254-20-1_425
REAR BRAKES DO NOT WORK
REAR BRAKES DO NOT WORK-cont.
REAR BRAKES DO NOT WORK - CONTINUED - TM-5-3805-254-20-1_428
REAR BRAKES DO NOT WORK - CONTINUED - TM-5-3805-254-20-1_429
REAR BRAKES DO NOT WORK - CONTINUED. - TM-5-3805-254-20-1_430
REAR BRAKES DO NOT WORK - CONTINUED. - TM-5-3805-254-20-1_431
REAR BRAKES DO NOT WORK - CONTINUED - TM-5-3805-254-20-1_432
REAR BRAKES DO NOT WORK - CONTINUED - TM-5-3805-254-20-1_433
PARKING BRAKE DOES NOT HOLD
PARKING BRAKE DOES NOT HOLD-cont.
PARKING BRAKE DOES NOT HOLD - CONTINUED - TM-5-3805-254-20-1_436
ORGANIZATIONAL TROUBLESHOOTING - CONTINUED - TM-5-3805-254-20-1_437
PARKING BRAKE DOES NOT HOLD - CONTINUED - TM-5-3805-254-20-1_438
PARKING BRAKE DOES NOT RELEASE
PARKING BRAKE DOES NOT RELEASE - CONTINUED - TM-5-3805-254-20-1_440
PARKING BRAKE DOES NOT RELEASE - CONTINUED - TM-5-3805-254-20-1_441
PARKING BRAKE DOES NOT RELEASE - CONTINUED - TM-5-3805-254-20-1_442
AIR SYSTEM DOES NOT HOLD AIR PRESSURE
AIR SYSTEM DOES NOT HOLD AIR PRESSURE - CONTINUED. - TM-5-3805-254-20-1_444
AIR SYSTEM DOES NOT HOLD AIR PRESSURE - CONTINUED. - TM-5-3805-254-20-1_445
BOTH WINDSHIELD WIPERS DO NOT WORK - TM-5-3805-254-20-1_446
BOTH WINDSHIELD WIPERS DO NOT WORK - TM-5-3805-254-20-1_447
ONE WINDSHIELD WIPER DOES NOT WORK - TM-5-3805-254-20-1_448
ONE WINDSHIELD WIPER DOES NOT WORK - TM-5-3805-254-20-1_449
STEERING SYSTEM
STEERING WHEEL DOES NOT TURN SMOOTHLY-cont.
POWER STEERING RESERVOIR OIL IS GRAY AND MURKY
STEERING WHEEL IS HARD TO TURN IN BOTH DIRECTIONS
STEERING WHEEL IS HARD TO TURN IN BOTH DIRECTIONS - CONTINUED - TM-5-3805-254-20-1_454
STEERING WHEEL IS HARD TO TURN IN BOTH DIRECTIONS - CONTINUED - TM-5-3805-254-20-1_455
STEERING WHEEL IS HARD TO TURN IN BOTH DIRECTIONS - CONTINUED - TM-5-3805-254-20-1_456
STEERING WHEEL IS HARD TO TURN IN BOTH DIRECTIONS - CONTINUED - TM-5-3805-254-20-1_457
STEERING WHEEL IS HARD TO TURN IN BOTH DIRECTIONS - CONTINUED - TM-5-3805-254-20-1_458
STEERING WHEEL IS HARD TO TURN IN BOTH DIRECTIONS - CONTINUED - TM-5-3805-254-20-1_459
STEERING WHEEL IS HARD TO TURN IN BOTH DIRECTIONS - CONTINUED - TM-5-3805-254-20-1_460
STEERING WHEEL IS HARD TO TURN IN BOTH DIRECTIONS - CONTINUED - TM-5-3805-254-20-1_461
STEERING WHEEL IS HARD TO TURN COUNTERCLOCKWISE - TM-5-3805-254-20-1_462
STEERING WHEEL IS HARD TO TURN COUNTERCLOCKWISE - TM-5-3805-254-20-1_463
STEERING WHEEL IS HARD TO TURN COUNTERCLOCKWISE - CONTINUED - TM-5-3805-254-20-1_464
STEERING WHEEL IS HARD TO TURN COUNTERCLOCKWISE - CONTINUED - TM-5-3805-254-20-1_465
STEERING WHEEL IS HARD TO TURN COUNTERCLOCKWISE - CONTINUED - TM-5-3805-254-20-1_466
STEERING WHEEL IS HARD TO TURN COUNTERCLOCKWISE - CONTINUED - TM-5-3805-254-20-1_467
STEERING WHEEL IS HARD TO TURN COUNTERCLOCKWISE - CONTINUED - TM-5-3805-254-20-1_468
STEERING WHEEL IS HARD TO TURN COUNTERCLOCKWISE - CONTINUED - TM-5-3805-254-20-1_469
STEERING WHEEL IS HARD TO TURN COUNTERCLOCKWISE - CONTINUED - TM-5-3805-254-20-1_470
STEERING WHEEL IS HARD TO TURN CLOCKWISE
STEERING WHEELS IS HARD TO TURN CLOCKWISE - CONTINUED - TM-5-3805-254-20-1_472
STEERING WHEELS IS HARD TO TURN CLOCKWISE - CONTINUED - TM-5-3805-254-20-1_473
STEERING WHEEL IS HARD TO TURN CLOCKWISE - CONTINUED - TM-5-3805-254-20-1_474
STEERING WHEEL IS HARD TO TURN CLOCKWISE - CONTINUED - TM-5-3805-254-20-1_475
STEERING WHEEL IS HARD TO TURN CLOCKWISE - CONTINUED - TM-5-3805-254-20-1_476
STEERING WHEEL IS HARD TO TURN CLOCKWISE - CONTINUED - TM-5-3805-254-20-1_477
STEERING WHEEL IS HARD TO TURN CLOCKWISE - CONTINUED - TM-5-3805-254-20-1_478
STEERING WHEEL IS HARD TO TURN CLOCKWISE - CONTINUED - TM-5-3805-254-20-1_479
DUMP BODY DOES NOT RAISE
DUMP BODY DOES NOT RAISE-cont.
DUMP BODY DOES NOT RAISE - CONTINUED - TM-5-3805-254-20-1_482
DUMP BODY DOES NOT RAISE - CONTINUED - TM-5-3805-254-20-1_483
DUMP BODY RAISES SLOWLY - TM-5-3805-254-20-1_484
DUMP BODY RAISES SLOWLY - TM-5-3805-254-20-1_485
DUMP BODY RAISES SLOWLY - CONTINUED.
DUMP BODY DOES NOT STAY UP
DUMP BODY DOES NOT STAY UP - CONTINUED
DUMP BODY DOES NOT LOWER
DUMP BODY DOES NOT LOWER - CONTINUED
PTO DOES NOT ENGAGE
PTO DOES NOT ENGAGE - CONTINUED - TM-5-3805-254-20-1_492
PTO DOES NOT ENGAGE - CONTINUED - TM-5-3805-254-20-1_493
Section VI. GENERAL MAINTENANCE INSTRUCTIONS
PRESHOP ANALYSIS - CONTINUED
CLEANING - CONTINUED - TM-5-3805-254-20-1_496
TAGGING PARTS - CONTINUED
WIRE REPLACEMENT
COTTER PINS
LINES AND PORTS - TM-5-3805-254-20-1_500
TUBES WITH COMPRESSION FITTINGS
TUBES WITH COMPRESSION FITTINGS - CONTINUED
ACCESS PROCEDURES
ACCESS PROCEDURES - CONTINUED - TM-5-3805-254-20-1_504
ACCESS PROCEDURES - CONTINUED - TM-5-3805-254-20-1_505
ACCESS PROCEDURES - CONTINUED - TM-5-3805-254-20-1_506
RIGHT INSTRUMENT PANEL
LOWER CENTER INSTRUMENT PANEL
UPPER CENTER INSTRUMENT PANEL
INSTRUMENT PANEL PAD
BATTERY BOX COVER
JACKING FRONT OF DUMP TRUCK
JACKING REAR OF DUMP TRUCK
BATTERY CABLES
BATTERY CABLES - CONTINUED
Section VII. FUEL SYSTEM MAINTENANCE
TURBOCHARGER PIPING - CONTINUED
CLEANING - TM-5-3805-254-20-1_518
INSPECTION/REPLACEMENT - TM-5-3805-254-20-1_519
INSPECTION/REPLACEMENT - CONTINUED - TM-5-3805-254-20-1_520
INSTALLATION - TM-5-3805-254-20-1_521
AIR CLEANER HOUSING
AIR CLEANER HOUSING - CONTINUED - TM-5-3805-254-20-1_523
AIR CLEANER HOUSING - CONTINUED - TM-5-3805-254-20-1_524
AIR CLEANER HOUSING - CONTINUED - TM-5-3805-254-20-1_525
DISASSEMBLY - CONTINUED - TM-5-3805-254-20-1_526
CLEANING - TM-5-3805-254-20-1_527
INSPECTION/REPLACEMENT - TM-5-3805-254-20-1_528
ASSEMBLY-cont. - TM-5-3805-254-20-1_529
INSTALLATION - TM-5-3805-254-20-1_530
INSTALLATION-cont. - TM-5-3805-254-20-1_531
AIR FILTER ELEMENT
AIR FILTER ELEMENT - CONTINUED - TM-5-3805-254-20-1_533
INSPECTION/REPLACEMENT - TM-5-3805-254-20-1_534
AIR FILTER ELEMENT - CONTINUED - TM-5-3805-254-20-1_535
ENGINE AUXILIARY OIL FILTER HOSES AND FITTINGS
ENGINE AUXILIARY OIL FILTER HOSES AND FITTINGS - CONTINUED - TM-5-3805-254-20-1_537
REMOVAL - CONTINUED - TM-5-3805-254-20-1_538
ENGINE AUXILIARY OIL FILTER HOSES AND FITTINGS - CONTINUED - TM-5-3805-254-20-1_539
ENGINE AUXILIARY OIL FILTER HOSES AND FITTINGS - CONTINUED - TM-5-3805-254-20-1_540
ENGINE AUXILIARY OIL FILTER HOSES AND FITTINGS - CONTINUED - TM-5-3805-254-20-1_541
ENGINE AUXILIARY OIL FILTER HOSES AND FITTINGS - CONTINUED - TM-5-3805-254-20-1_542
ENGINE AUXILIARY OIL FILTER HOSES AND FITTINGS - CONTINUED - TM-5-3805-254-20-1_543
ENGINE AUXILIARY OIL FILTER SHELL
ENGINE AUXILIARY OIL FILTER SHELL - CONTINUED - TM-5-3805-254-20-1_545
INSPECTION/REPLACEMENT - TM-5-3805-254-20-1_546
ENGINE AUXILIARY OIL FILTER SHELL - CONTINUED - TM-5-3805-254-20-1_547
ENGINE AUXILIARY OIL FILTER SHELL - CONTINUED - TM-5-3805-254-20-1_548
ENGINE AUXILIARY OIL FILTER SHELL - CONTINUED - TM-5-3805-254-20-1_549
PRIMARY FUEL FILTER
PRIMARY FUEL FILTER - CONTINUED - TM-5-3805-254-20-1_551
CLEANING - TM-5-3805-254-20-1_552
PRIMARY FUEL FILTER - CONTINUED - TM-5-3805-254-20-1_553
PRIMARY FUEL FILTER HOUSING
PRIMARY FUEL FILTER HOUSING - CONTINUED - TM-5-3805-254-20-1_555
PRIMARY FUEL FILTER HOUSING - CONTINUED - TM-5-3805-254-20-1_556
INSPECTION/REPLACEMENT - TM-5-3805-254-20-1_557
INSTALLATION - TM-5-3805-254-20-1_558
PRIMARY FUEL FILTER HOUSING - CONTINUED - TM-5-3805-254-20-1_559
SECONDARY FUEL FILTER
FUEL PUMP FUEL FILTER
REMOVAL - TM-5-3805-254-20-1_562
INSPECTION/REPLACEMENT - TM-5-3805-254-20-1_563
INSTALLATION - TM-5-3805-254-20-1_564
PRIMING FUEL SYSTEM
FILLING PRIMARY FUEL FILTER - CONTINUED
FILLING FUEL PUMP
PREHEATER PRIMER PUMP
PREHEATER PRIMER PUMP - CONTINUED - TM-5-3805-254-20-1_569
INSTALLATION - TM-5-3805-254-20-1_570
PREHEATER PRIMER PUMP - CONTINUED - TM-5-3805-254-20-1_571
PREHEATER PRIMER PUMP FUEL LINES AND FITTINGS
PREHEATER PRIMER FUEL PUMP FUEL LINES AND FITTINGS - CONTINUED
PREHEATER PRIMER PUMP FUEL LINES AND FITTINGS - CONTINUED - TM-5-3805-254-20-1_574
PREHEATER PRIMER PUMP FUEL LINES AND FITTINGS - CONTINUED - TM-5-3805-254-20-1_575
REMOVAL - CONTINUED - TM-5-3805-254-20-1_576
PREHEATER PRIMER PUMP FUEL LINES AND FITTINGS - CONTINUED - TM-5-3805-254-20-1_577
PREHEATER PRIMER PUMP FUEL LINES AND FITTINGS - CONTINUED - TM-5-3805-254-20-1_578
PREHEATER PRIMER PUMP FUEL LINES AND FITTINGS - CONTINUED - TM-5-3805-254-20-1_579
PREHEATER PRIMER PUMP FUEL LINES AND FITTINGS - CONTINUED - TM-5-3805-254-20-1_580
CLEANING - TM-5-3805-254-20-1_581
INSPECTION/REPLACEMENT - TM-5-3805-254-20-1_582
PREHEATER PRIMER PUMP FUEL LINES AND FITTINGS - CONTINUED - TM-5-3805-254-20-1_583
PREHEATER PRIMER PUMP FUEL LINES AND FITTINGS - CONTINUED - TM-5-3805-254-20-1_584
PREHEATER PRIMER PUMP FUEL LINES AND FITTINGS - CONTINUED - TM-5-3805-254-20-1_585
INSTALLATION - TM-5-3805-254-20-1_586
PREHEATER PRIMER PUMP FUEL LINES AND FITTINGS - CONTINUED - TM-5-3805-254-20-1_587
INSTALLATION - CONTINUED - TM-5-3805-254-20-1_588
PREHEATER PRIMER PUMP FUEL LINES AND FITTINGS - CONTINUED - TM-5-3805-254-20-1_589
INSTALLATION - CONTINUED - TM-5-3805-254-20-1_590
PREHEATER PRIMER PUMP FUEL LINES AND FITTINGS - CONTINUED - TM-5-3805-254-20-1_591
INSTALLATION - CONTINUED - TM-5-3805-254-20-1_592
PREHEATER PRIMER PUMP FUEL LINES AND FITTINGS - CONTINUED - TM-5-3805-254-20-1_593
PREHEATER PRIMER PUMP NOZZLE
PREHEATER PRIMER PUMP NOZZLE - CONTINUED
GLOW PLUG
GLOW PLUG - CONTINUED
DRAINING FUEL TANKS
DRAIN FUEL TANKS - CONTINUED
FUEL GAGE SENDING UNIT
FUEL GAGE SENDING UNIT - CONTINUED - TM-5-3805-254-20-1_601
FUEL GAGE SENDING UNIT - CONTINUED - TM-5-3805-254-20-1_602
FUEL GAGE SENDING UNIT - CONTINUED - TM-5-3805-254-20-1_603
FUEL TANK VENT HOSES
FUEL TANK VENT HOSES - CONTINUED
INSTALLATION - TM-5-3805-254-20-1_606
FUEL TANK STRAPS
FUEL TANK STRAPS - CONTINUED - TM-5-3805-254-20-1_608
FUEL TANK STRAPS - CONTINUED - TM-5-3805-254-20-1_609
FUEL TANK STRAPS - CONTINUED - TM-5-3805-254-20-1_610
FUEL TANK STRAPS - CONTINUED - TM-5-3805-254-20-1_611
FRONT FUEL TANK
FRONT FUEL TANK - CONTINUED - TM-5-3805-254-20-1_613
REMOVAL - CONTINUED - TM-5-3805-254-20-1_614
FRONT FUEL TANK - CONTINUED - TM-5-3805-254-20-1_615
INSPECTION - TM-5-3805-254-20-1_616
ASSEMBLY - TM-5-3805-254-20-1_617
INSTALLATION - TM-5-3805-254-20-1_618
FRONT FUEL TANK - CONTINUED - TM-5-3805-254-20-1_619
INSTALLATION - CONTINUED - TM-5-3805-254-20-1_620
INITIAL SETUP - TM-5-3805-254-20-1_621
REMOVAL - TM-5-3805-254-20-1_622
DISASSEMBLY - TM-5-3805-254-20-1_623
DISASSEMBLY - CONTINUED - TM-5-3805-254-20-1_624
ASSEMBLY - TM-5-3805-254-20-1_625
ASSEMBLY - CONTINUED - TM-5-3805-254-20-1_626
INSTALLATION-cont. - TM-5-3805-254-20-1_627
FILLING FRONT FUEL TANK
FILLING FRONT AND REAR FUEL TANKS
FUEL TANK SUPPORTS
FUEL TANK SUPPORTS - CONTINUED - TM-5-3805-254-20-1_631
CLEANING - CONTINUED - TM-5-3805-254-20-1_632
FUEL TANK SUPPORTS - CONTINUED - TM-5-3805-254-20-1_633
ACCELERATOR CONTROL ROD
ACCELERATOR CONTROL ROD - CONTINUED - TM-5-3805-254-20-1_635
ACCELERATOR CONTROL ROD - CONTINUED - TM-5-3805-254-20-1_636
ACCELERATOR CONTROL ROD - CONTINUED - TM-5-3805-254-20-1_637
ASSEMBLY - TM-5-3805-254-20-1_638
ACCELERATOR CONTROL ROD - CONTINUED - TM-5-3805-254-20-1_639
INSTALLATION - CONTINUED - TM-5-3805-254-20-1_640
ACCELERATOR CONTROL ROD - CONTINUED - TM-5-3805-254-20-1_641
ADJUSTMENT - TM-5-3805-254-20-1_642
ADJUSTMENT - TM-5-3805-254-20-1_643
ADJUSTMENT - CONTINUED - TM-5-3805-254-20-1_644
ACCELERATOR CONTROL ROD - CONTINUED - TM-5-3805-254-20-1_645
ACCELERATOR CONTROL LEVER
REMOVAL-cont. - TM-5-3805-254-20-1_647
CLEANING - TM-5-3805-254-20-1_648
INSPECTION - TM-5-3805-254-20-1_649
INSTALLATION - TM-5-3805-254-20-1_650
FOLLOW-ON MAINTENANCE - TM-5-3805-254-20-1_651
ACCELERATOR CONTROL PIVOT ARM
ACCELERATOR CONTROL PIVOT ARM - CONTINUED
REMOVAL - CONTINUED - TM-5-3805-254-20-1_654
INSPECTION - TM-5-3805-254-20-1_655
INSTALLATION - TM-5-3805-254-20-1_656
INSTALLATION-cont. - TM-5-3805-254-20-1_657
ACCELERATOR CONTROL PEDAL
REMOVAL - TM-5-3805-254-20-1_659
CLEANING - TM-5-3805-254-20-1_660
INSTALLATION - TM-5-3805-254-20-1_661
ADJUSTMENT - TM-5-3805-254-20-1_662
ADJUSTMENT-cont. - TM-5-3805-254-20-1_663
HAND THROTTLE CONTROL
REMOVAL - TM-5-3805-254-20-1_665
REMOVAL - CONTINUED - TM-5-3805-254-20-1_666
REMOVAL - CONTINUED - TM-5-3805-254-20-1_667
CLEANING - TM-5-3805-254-20-1_668
CLEANING-cont. - TM-5-3805-254-20-1_669
INSTALLATION - TM-5-3805-254-20-1_670
INSTALLATION-cont. - TM-5-3805-254-20-1_671
ADJUSTMENT - TM-5-3805-254-20-1_672
FOLLOW-ON MAINTENANCE - TM-5-3805-254-20-1_673
Section VIII. EXHAUST SYSTEM MAINTENANCE
EXHAUST PIPE - CONTINUED - TM-5-3805-254-20-1_675
EXHAUST PIPE - CONTINUED - TM-5-3805-254-20-1_676
EXHAUST PIPE - CONTINUED - TM-5-3805-254-20-1_677
INSPECTION/REPLACEMENT - TM-5-3805-254-20-1_678
EXHAUST PIPE - CONTINUED - TM-5-3805-254-20-1_679
INSTALLATION - TM-5-3805-254-20-1_680
EXHAUST PIPE - CONTINUED - TM-5-3805-254-20-1_681
INSTALLATION - CONTINUED - TM-5-3805-254-20-1_682
INSTALLATION - CONTINUED - TM-5-3805-254-20-1_683
EXHAUST DIVERTER
CLEANING - TM-5-3805-254-20-1_685
INSPECTION/REPLACEMENT - TM-5-3805-254-20-1_686
FOLLOW-ON MAINTENANCE - TM-5-3805-254-20-1_687
MUFFLER AND RAIN CAP
DISASSEMBLY - TM-5-3805-254-20-1_689
DISASSEMBLY - CONTINUED - TM-5-3805-254-20-1_690
INSPECTION/REPLACEM ENT
INSPECTION/REPLACEMENT - CONTINUED - TM-5-3805-254-20-1_692
INSTALLATION - TM-5-3805-254-20-1_693
INSTALLATION - CONTINUED - TM-5-3805-254-20-1_694
MUFFLER AND RAIN CAP - CONTINUED
REMOVAL - TM-5-3805-254-20-1_696
INSPECTION/REPLACEMENT - TM-5-3805-254-20-1_697
INSTALLATION - TM-5-3805-254-20-1_698
EXHAUST DIVERTER BRACKET SUPPORTS
REMOVAL - TM-5-3805-254-20-1_700
REMOVAL-cont. - TM-5-3805-254-20-1_701
INSTALLATION - TM-5-3805-254-20-1_702
EXHAUST PIPE FRONT HANGER
REMOVAL - TM-5-3805-254-20-1_704
EXHAUST PIPE REAR HANGER
INSPECTION/REPLACEMENT - TM-5-3805-254-20-1_706
EXHAUST PIPE REAR HANGER - CONTINUED
MUFFLER UPPER SUPPORT
INSPECTION/REPLACEMENT - TM-5-3805-254-20-1_709
INSTALLATION - TM-5-3805-254-20-1_710
MUFFLER UPPER SUPPORT - CONTINUED
Section IX. COOLING SYSTEM MAINTENANCE
DRAINING - TM-5-3805-254-20-1_713
RADIATOR - CONTINUED - TM-5-3805-254-20-1_714
RADIATOR - CONTINUED - TM-5-3805-254-20-1_715
REFILLING - CONTINUED
THERMOSTAT - TM-5-3805-254-20-1_717
THERMOSTAT - CONTINUED - TM-5-3805-254-20-1_718
THERMOSTAT - CONTINUED - TM-5-3805-254-20-1_719
WATER PUMP BELT ADJUSTMENT
WATER FILTER
WATER FILTER - CONTINUED
RADIATOR OUTLET HOSE
RADIATOR OUTLET HOSE - CONTINUED
INSPECTION/REPLACEMENT - TM-5-3805-254-20-1_725
INSTALLATION - TM-5-3805-254-20-1_726
RADIATOR VENT HOSE
REMOVAL - TM-5-3805-254-20-1_728
INSPECTION/REPLACEMENT - CONTINUED - TM-5-3805-254-20-1_729
RADIATOR VENT HOSE - CONTINUED - TM-5-3805-254-20-1_730
RADIATOR VENT HOSE - CONTINUED - TM-5-3805-254-20-1_731
RADIATOR INLET HOSE
REMOVAL - CONTINUED - TM-5-3805-254-20-1_733
INSPECTION/REPLACEMENT - TM-5-3805-254-20-1_734
INSTALLATION - TM-5-3805-254-20-1_735
RADIATOR BYPASS COOLANT LINE
REMOVAL - TM-5-3805-254-20-1_737
INSPECTION/REPLACEMENT - TM-5-3805-254-20-1_738
INSPECTION/REPLACEMENT - CONTINUED - TM-5-3805-254-20-1_739
RADIATOR BYPASS COOLANT LINE - CONTINUED
RADIATOR HOSE
RADIATOR HOSE - CONTINUED - TM-5-3805-254-20-1_742
INSPECTION/REPLACEMENT - TM-5-3805-254-20-1_743
RADIATOR HOSE - CONTINUED - TM-5-3805-254-20-1_744
INSTALLATION - TM-5-3805-254-20-1_745
RADIATOR HOSE - CONTINUED - TM-5-3805-254-20-1_746
INITIAL SETUP - TM-5-3805-254-20-1_747
RADIATOR DEAERATION HOSE - CONTINUED - TM-5-3805-254-20-1_748
INSPECTION/REPLACEMENT - TM-5-3805-254-20-1_749
RADIATOR DEAERATION HOSE - CONTINUED - TM-5-3805-254-20-1_750
FRONT WATER MANIFOLD HOSE
FRONT WATER MANIFOLD HOSE - CONTINUED
INSPECTION/REPLACEMENT - TM-5-3805-254-20-1_753
INSTALLATION - TM-5-3805-254-20-1_754
AIR COMPRESSOR COOLANT HOSES
AIR COMPRESSOR COOLANT HOSES - CONTINUED - TM-5-3805-254-20-1_756
AIR COMPRESSOR COOLANT HOSES - CONTINUED - TM-5-3805-254-20-1_757
WATER FILTER HOSES
INSPECTION/REPLACEMENT - TM-5-3805-254-20-1_759
WATER FILTER HOSES - CONTINUED
FAN DRIVEBELT
INSPECTION/REPLACEMENT - TM-5-3805-254-20-1_762
FAN DRIVEBELT - CONTINUED

Western Governors University

Privacy Statement
Press Release
Contact

Integrated Publishing, Inc. - A (SDVOSB) Service Disabled Veteran Owned Small Business